chinacoal05
www.chinacoalintl.com
m.chinacoalintl.com
we provide service of enterprise's customs declaration, inspection.
Product Detail:
Mortar mixer has the features of reasonable structure, good mixing
quality, mixing time is short, low energy consumption, low noise.
Suitable for mixing dry hard, semi-hard, plastic and various
proportions of the concrete,and it can meet different application
requirements.
Mortar mixer consists of the mixing tube, shaft, gear, chassis and
other components, mortar mixer can be used for building metallurgy,
railway bridges, pre-stressed components such as the construction
and maintenance.
Instructions
1. the loaded ash, sand and other materials, the max particle size
not greater than 5 mm, not mixed with gravel and other debris (such
as nails, vegetation, etc.).
2. Ratio of slurry:according to mortar pump using materials
selection and configuration.
3. the mixing mortar pump slurry consistency meet the requirements.
Operating instruction
1. the installation of mortar mixer should be smooth firm, walking
round shall stand suspended, base should be boosted out of the
ground. In the vicinity of the installation should take the
fortified building smashing, anti-canopy.
2. check the electrical equipment before operation, leakage
protection and reliable then zero or ground protection;
transmission parts, complete and effective safety devices, only
after confirming that no abnormal test run.
3. the operation when the first start, to be operating normally,
before feeding and water, stirring, add enough material shall be
then vigorously. Sand should be sifted, feeding excess is strictly
prohibited.
4. the use of tools should be higher than when feeding a stirring
blade, non-operation of the tool inserted into the mixing tube
steak material.
5. large debris falling into the mixing tube, you must stop and
then check in hand to pick up fishing prohibited operation.
6. running non-maintenance, found stuck or abnormal, should be shut
down and then wind up troubleshooting.
7. the job is completed, you must cut off the power, unplug the
power plug (pin), and water will be cleaned inside and outside
mortar mixer (non-electrical equipment when cleaning water) before
leaving.
Technical Parameter
1. Capacity； 180L
2. Motor power: 2.2KW
3. Rotation speed: 70r/min
4. Mixing capacity: 6m3/h
5. Weight: 200kg
6. Feeding height:980mm
7. Our size : dia*height: 900 * 1146(mm * mm)
